Questions tagged [diesel]

A type of internal combustion engine where ignition happens when fuel is spray at high pressure into a compressed charge of air, or the relatively heavy fuel oil used in compression-ignition engines.

80 questions with no upvoted or accepted answers
Filter by
Sorted by
Tagged with
4
votes
0answers
74 views

Results surprising said lab reporter of emission testing on Toyota Qualis Diesel 4 wheeler on AVL DiTest MDS 205

I got emissions of Toyota Qualis Diesel car tested with the AVL DiTest MDS 205, the result sheet had following columns rpm, temp, secs, CO(%vol.), CO corrected, CO2(% vol.), HC(ppm),HC corrected(ppm),...
4
votes
0answers
95 views

Why do so many diesel engines have problems with aluminum oxide in the cooling systems?

I have a bad case of aluminum oxide contamination in my 98 Mazda 626's cooling system. While researching the subject, and filtration solutions, I noticed that this type of problem is very common ...
4
votes
0answers
573 views

Diesel car struggles to start when cold

Recently had the timing belt, water pump, all valves and rocker arms, fuel filter, oil filter, air filter changed on my 2006 Audi A3 8P 2.0 TDI 140. I've had it back for two days now and it struggles ...
4
votes
0answers
283 views

1989 7.3 IDI wont start

I have a 1987 F250 with a 1989 7.3 IDI swap, the truck always used to run great. I went outside to try and fire her up and she wont start. I've tried plugging in the block heater and using ether. It ...
4
votes
0answers
234 views

Running in oil a for light diesel engine (Japanese, Toyota 3L)?

What would you use as a running in (break-in) oil for this engine? I have this engine, and it has just been reconditioned, new pistons, conrods, crank and bearings.
4
votes
0answers
471 views

Excursion SuperDuty Cannot Calibrate Speedometer

I have an 02 Excursion Limited Diesel and cannot get the speedometer calibrated. I purchased the vehicle with 35" tires (original equipment is 32") The tires were about 75% worn and the speedometer ...
4
votes
1answer
3k views

Lag at accelerating and/or loss of power

This may be a long shot. So, I have a Renault Megane 2, with a 2.0l Diesel engine with theoretical 150hp and 340Nm of torque. The thing that worries me is that when I push the pedal, it just takes ...
3
votes
1answer
31 views

2000 Daewoo Musso 2.9 TDI Engine shaking heavily in idle, getting better in higher RPMs

I bought my first project car dirt cheap it's a Daewoo (Ssangyong) Musso Diesel SUV which has one of the most reliable engines, the Mercedes OM602 This car is starting fine but the Engine is shaking ...
3
votes
1answer
36 views

Have 01 Dodge ram 2500 desiel automatic transmission

Transmission started making grinding noise on way home. Took forever change gears put it in my garage dropped transmission found round bearings in bell housing. I can't tell if they were from front ...
3
votes
0answers
283 views

Renault Megane not starting after water damage

Im looking at a Renault Megane 2010 1.5 dci which was crashed into a drain. ECU and electrics on left hand side were submerged. Have changed ECU, circuit box on top of left suspension, circuit box by ...
3
votes
0answers
38 views

Diesel engine smoking

So I am currently working on a Ford Transit 2013 Diesel. The vehicle had a startup problem. I went ahead to change the turbo, fuel filter, and even had to extract the DPF from its chamber (because ...
3
votes
0answers
1k views

Does BMW use piezo-injectors for all their diesel engines since N57?

I've heard rumors that since piezo-injectors in N57s proven to be unreliable, BMW switched back to solenoid-type injectors in later engines. Now I see piezo-type in B57 specs. My question is what ...
3
votes
0answers
557 views

Meaning of P0245 (16629) DTC on VW ALH TDI Engine

I'm seeing a P0245/16629 – Solenoid Valve (A) for Boost Pressure Control (N75): Short to Ground – code on our 2002 ALH TDI. The solenoid valve controls the boost by moving the vacuum actuator that ...
3
votes
0answers
572 views

Mahindra KUV 100 and Suzuki Alto OBD protocol

Can someone please tell me the OBD-II protocol of Mahindra KUV 100 (diesel) and Suzuki Alto (diesel). Also whether ELM 327 Bluetooth will work? http://www.ebay.in/itm/SuperMini-ELM-327-Bluetooth-v2-...
3
votes
0answers
429 views

Hyundai Tucson died while driving; will not start

I have a Hyundai Tucson 2011 directed injected diesel which has just broken down. What happened is that while driving the engine suddenly stopped and won't start. There is no check engine light on. ...
2
votes
3answers
203 views

Jump-starting high-amperage diesel engine with a car with a smaller battery

I have a 1985 Mercedes 300d, with a battery with a cold-crank rating of 1000 amps. The battery is pretty much dead (and pretty much new). So far, I haven't been able to jump-start it with another car ...
2
votes
0answers
253 views

Mixing DEF with Diesel

DEF (Diesel Exhaust Fluid) is a solution of urea and water. What exactly happens if DEF is inadvertently added to the diesel tank? This YouTube video: https://www.youtube.com/watch?v=aLwcm4PjyIs ...
2
votes
0answers
36 views

What is this connection on the air intake right before the turbo?

This is the engine bay of a Citroën C5. I would like to know what the connection indicated by the red square is for. I removed the air duct once to check the EGR valve and there was a little oil ...
2
votes
0answers
210 views

High Oil consumption in my BMW x3 - 2014 - (F25) 2L Diesel engine

i have recently got my BMW x3 with 41,000 km on it after running for some time it asked for a oil 1L oil topup so i called BMW dealership and they asked me to get a castrol 5w30 and top it up and i ...
2
votes
0answers
24 views

astravan td intermittently stalling at low revs when warm

my 05 vauxhall astravan 1.7TD can run fine for a couple of weeks then out of the blue it stalls at low revs when warm. It will restart ok but will not tick over. Once cool it could be ok again for a ...
2
votes
0answers
2k views

P1461 - EGR (Exhaust Gas Recycling) error, what does this mean

Each time I turn on the engine it says Depollution System Faulty, the diagnosis says "P1461 | Exhaust Gas Recycling Electric Valve Copy Signal Valve Low Limit Drift Since First Start - up ..." I ...
2
votes
0answers
53 views

A180 diesel doesn't start, pops open diesel cap instead

When I try to start my diesel Mercedes A180 it doesn't start and the diesel cap opens instead! When I turn the key, sometimes it makes the starting noise (but then stops). At other times it doesn't ...
2
votes
0answers
84 views

Om mercedes 364 turbo diesel fuel line question

Hello I'm busy with a conversion on a om 364 Turbo mercedes Benz diesel engine. I am battling to find a diagram for the fuel lines and which is the push and return fuel lines on this motor and where ...
2
votes
1answer
2k views

How do I resolve acceleration issues with my Mahindra Bolero?

I have acceleration issues my Mahindra Bolero. This happened after I got the thermostat replaced. I have check with couple of workshops and ended up changing diesel filer and accelerator kit. ...
2
votes
0answers
148 views

Fuel pump fuse location

Where is the fuse for the fuel Pump located in the fuse relay box for a 2004 Dodge Ram 2500? I am trying to find out if I need to change my fuel pump or just the fuse. I am not getting any readings ...
2
votes
0answers
46 views

Looking for Fuel Injectors for a Renault Clio Expression 1.5 cdi 2006 plate

I am looking at buying a set of fuel injectors for my car but not sure of what part number I can use. Equally can you buy a manual for car parts? Any help would be appreciated. Thanks in advance.
2
votes
0answers
1k views

Slipping Automatic Transmission when Cold

Car: VW Touareg 2007 2.5 TDI 90,000 Miles Symptoms: Does not engage the clutch plates when cold and slips in all gears. When you take your foot off the accelerator, the revs drop down to idle while ...
2
votes
0answers
665 views

Catalyst Temperature

Please refer to Catalyst Temperature PIDs (mode 01 pids 3C, 3D, 3E, 3F) for the following questions - https://en.wikipedia.org/wiki/OBD-II_PIDs#Mode_01 Q1. Is there a thumb rule that the catalyst ...
2
votes
0answers
2k views

Troubleshooting Smoking Diesel (2002 VW ALH TDI)

Our 2002 TDI has started surging at idle – especially in gear after a cold start, it seems to get better as the car warms up – and smoking (mostly HB's, vile habit). This has been going on for about a ...
2
votes
0answers
454 views

Hot cranking problem on 6.6 duramax

6.6 duramax diesel engine cranks good cold but periodically won't crank hot unless I use starting fluid. This usually happens after engine has been turned off about 30 minutes. Also if idles for ...
2
votes
0answers
2k views

BMW 520d e60 2008 diesel engine won't start after switching off

I have a strange behaviour of my car. Engine starts well at any weather condition but after driving and switched off engine cannot start again for 20 - 40 minutes. After this time it starts like ...
2
votes
0answers
2k views

Volvo D13 Boost and fuel mileage problem

My Volvo diesel D13 creates boost at low RPM's at various amounts of level and at any given time; the fuel mileage has gone down by 1.5 miles per gallon. The waste gate was replaced and the computer ...
1
vote
0answers
20 views

2012 Great Wall V200 Turbo Diesel injector coding

I have recently installed second hand injectors. I have software to reprogram the injectors into the ECU. However, it continues to come up with an error when I enter the new injector code. I have been ...
1
vote
0answers
21 views

Mazda 6 MZR-CD diesel fuel issue

I have a mazda 6 mzr-cd turbo diesel wagon 2009 model. I just purchased the car and after trying to jump the car i thought the engine had no compression. However after trying again with a stronger ...
1
vote
0answers
22 views

One reverse light stays

One reverse light stays on when running on my 2012 Dodge Ram. Where do I start looking to solve this issue?
1
vote
0answers
26 views

What does a high altitude package in diesel heatings

I am currently checking out various camper vans and for one manufacturer there is an option for the diesel heating called "high altitude package" which is supposed to ensure the heating is functioning ...
1
vote
0answers
40 views

2011 Jeep Patriot CRD 2.2 - engine does not start // P0685 error

I have a 2011 Jeep Patriot CRD 2.2 (Euro-Model) that does not start anymore. First boot-up and preheating is normal but when I turn the key further for ignition nothing happens, no sound no movement, ...
1
vote
0answers
16 views

2007 F250 Super duty Powerstroke 6.0 crank no start

Ok I don't know Jack about diesel, but i am learning as I go! It has been running out of fuel when the DTE is at 65-58 miles and its keeps climbing. When i first got the truck a year ago it ran out at ...
1
vote
1answer
198 views

Land Rover Freelander 2 - Bad MPG

2007 Freelander 2 Was having what I consider bad MPG for a diesel, averaging around 23-24mpg Initially thought it needs a service, so lots of money later for a full service which would have ...
1
vote
0answers
18 views

Polo 9n SDI 2002

Help :-) My son has bout a polo 9n sdi with 120000 miles on. It was a bit smokey apperantly when he bought it. I now have it here on my drive and it smokes on idle and has a neat smoke screen trick ...
1
vote
0answers
62 views

Kindly please help my Jetta 4 tdi not starting after engine overhaul, showing the error codes below

My Jetta 4 tdi not starting showing those error codes
1
vote
2answers
161 views

Isuzu D-max 3.0 2009 port OBDII

I'm not a mechanic or anything, but I'm too curious. I live in Colombia and I have a vehicle that is marketed here as Chevrolet Isuzu D-max 3.0 model 2009 (diesel engine) I know that my vehicle has ...
1
vote
0answers
71 views

Priming fuel system from fuel tank?

Mechanic changed my Focus 2014`s diesel fuel filter, then because he didn't know the correct method to bleed the system, instead he pressurized the fuel tank with compressor. Car ran fine. But the ...
1
vote
0answers
341 views

Diesel engine struggling to start when cold

I have a 2.7D Ford AJD-V6/PSA DT17 diesel engine, on which I recently replaced 3 fuel injectors (all 3 of them were leaking). After the injectors were replaced, I now encounter the following problem: ...
1
vote
0answers
47 views

BMW 318d 2006 e90 Starter Problem?

I have this weird issue, where my BMW starts When Its cold, but once the car heats up, It turns over after a couple of tries sometimes (10-20) sometimes it will not turn over at all, when that happens ...
1
vote
1answer
847 views

Suspected suction control valve issue, car also hard to start

I drive a Toyota Corolla with a 1AD-FTV engine. This car has become progressively harder to start over the years. Even at 10°C it might take two tries. It still starts without too much trouble, if you ...
1
vote
0answers
220 views

Ford Figo 2012 dash board low fuel problem

I am using 2012 Ford Figo Diesel Model and currently I am getting an error in my dashboard like low fuel warning even though diesel tank having 1/2 of its capacity. Due to that its not allowing to ...
1
vote
0answers
568 views

BMW 520D M Sport 2008 - Loses power then fails to start shortly after

First had this issue 6 months ago, Engine slowly stalled then when attempting to restart it died out after 10-15 seconds of running with some smoke coming from the front of the engine. Diagnosis was ...
1
vote
0answers
54 views

What are the common parts within the 2 and 4 stroke diesel engines?

What are the common parts within the 2 and 4 stroke diesel engines. a) Piston, valves, cylinder, fuel injector b) Crankshaft, crosshead, cylinder c) Turbocharger, piston, gudgeonpin, cylinder d) ...
1
vote
0answers
190 views

BMW 318d 2006 E90 - DPF Filter?

I have a BMW 318d 2006, and it has been acting weird for a couple of days now, I have researched that some of the 318d have DPF filters and some Don't, my problem is where I drive to work 200km there ...