2

I noticed a knocking noise on my Ford Focus 1.8tdci 74kw from 2004. The car is old, so it might be the end for it. Nevertheless, I would like to diagnose the problem if possible. You can hear the noise here.

The knock comes from the accessory belt side of the engine. I don't think it comes from a pulley, since the noise is there with the belt off. The noise goes away after 2000rpm. It seems to me like a chirping sound is audible at 2000 rpm, not at the same frequency as the motor rpm.

Also the noise is not present when the car is not in load (when decelerating with the gas pedal lifted). No error codes are present, no smoke, no vibrations, the car was never low on oil. I did not feel any loss of power.

I am thinking:

  • chain? the sound is not a rattle. It's like two pieces of metal knocking.
  • injectors? I heard bad injectors can give engine knocking
  • rod knocking? The car doesn't sound as bad as cars having this issue on youtube.
  • exhaust leak?

Thanks in advance.

1
  • There is a metallic tick, could be an exhaust leak coupled with either a water pump bout to go, oil pump, crank bearing, or pushrod. Could Be..... Hope it helps, good luck. Nov 12, 2022 at 2:23

4 Answers 4

2

This sounds nothing like a knock to me, or anything internal to the engine. It appears to be running really well from what I can hear. It sounds like you have an exhaust leak. You need to scour the exhaust from exhaust manifold past the turbo to figure out if there is an issue there.

2
  • Thanks for the advice/encouragement! :) I will search for exhaust leaks. Nov 7, 2022 at 21:27
  • It seems there were at least three problems with my belts. The timing belt was loose, the tensioner was worn out. The drive belt tensioner was also out. Changed the timing belt and both tensioners and the noise is almost gone. There is still something coming from the accesory belts. I tend to believe it's the alternator pulley since the noise almost disappears when the alternator is in charge (lights on, defrost on). Nov 26, 2022 at 23:53
1

I would check the harmonic damper (main crankshaft pulley). When the rubber fails, they can make a 'ding ding ding' metallic noise.

With the ancillary belt removed, check if there is any play between the inside and outside diameters of the pulley.

1
  • I will check that. Although, it was changed two years ago. I remember when it failed it made the "ding" sound over bumps, since the metal parts would collide then. Nov 8, 2022 at 13:57
1

The oil pump may be worn out and it may be that sufficient RPM is needed to generate oil pressure. Rod knock from low oil pressure can sneak up on you and begin as a moderate sound that is not as intense as the stereotypical rod knock youtube video. Find a way to measure the oil pressure.

Try removing all the accessory belts to see if the noise goes away when no accessories are present, thus ruling out one of those components.

1

There seem to be at least two or three simultaneous problems. I did two things which eliminated most of the noises.

Partial solve:

  1. The tensioner pulley for the timing belt was worn out (although the km limit was not reached and it had 4 years out of the 5 it is supposed to hold). I opened the cover and the belt was quite loose, I guess the tensioner did not hold the belt right anymore. Tightening the tensioner already removed some of the more nasty metal on metal noises. I changed the timing belt and tensioner.

  2. Since there were noises on the accessory belt part I replaced the tensioner there too. It diminished again the noise and removed the squeaking noise at high rpm.

I only talk about a partial solution since there is still some noise remaining on the accesories belt. I tend to believe it comes from the alternator pulley, since the noise decreases every time I put a charge on the alternator (lights, rear window defrost, etc).

At least the noise doesn't come from the inside the engine. :)

2
  • 1
    I'm happy you've diagnosed most of your issue. In defense of my answer, it's sometimes really hard to diagnose from video sound :o) Thank you for posting up what you've found so far ... please come back and edit this answer further to completely answer what's going on! Nov 26, 2022 at 23:57
  • I am well aware that diagnosing a noise by listening a video is very difficult. Nevertheless, thank you for your advice. Nov 28, 2022 at 11:59

You must log in to answer this question.

Not the answer you're looking for? Browse other questions tagged .