My 92 Civic has had low power (need to use at least one gear lower than usual to get the same power) and has been getting bad gas mileage (15-25mpg vs 32-42 mpg usual) since I replaced the head gasket. Exhaust also smells bad. Engine is otherwise running very smooth and quiet, though. I'm looking for some help diagnosing what the source of the problem might be. Here's some additional information:

  • Timing belt slipped and might be off by 1-2 notches, but seemed to be right when I lined it back up (I aligned the UP marking on the cam sprocket with TDC as measured by sticking a rod down through the #1 spark plug hole).

  • Oxygen sensor was shot (completely covered in soot and outputting -0.1v instead of 0.1v-0.9v) but has been replaced. That improved the situation somewhat, but not fully. I measured the voltage from the new O2 sensor and it's never getting above 0.1v. Could this result from incomplete combustion (oxygen left after combustion) and if so, what might the cause be?

  • Fuel filter was also replaced and fuel delivery system seems to be fine, but I don't know how to measure fuel pressure or pressure in the intake system.

Any ideas?

  • 2
    ...so timing belt is currently off 1-2 notches, or was of 1-2 notches and has since been corrected?
    – mac
    Commented Nov 16, 2012 at 15:29
  • It could be. As far as I could tell, I got it right, but it's the first time I've ever realigned it. Commented Nov 16, 2012 at 19:11
  • Exhaust smell has gone away and fuel efficiency is up to about 22-32 (city vs highway) since replacing the O2 sensor. I've got a local shop I trust to check it out further and I ran by them a list of things I thought might be wrong, so I think I'll just get them to check it out. I wouldn't want to pay ~$60 for a single-point test, but it sounds like they'll be able to cover all bases for the standard diagnostic cost, which sounds pretty reasonable to me. Commented Nov 26, 2012 at 20:19
  • Could you update your post to include problems you are still having after replacing the O2 sensor? Commented Dec 12, 2012 at 0:09

2 Answers 2


Tried a lot of things, some of which helped incrementally but didn't fully fix the problem:

  • Torquing the exhaust manifold nuts to spec.
  • Replacing the muffler.

Finally took it to a shop for diagnosis and they found that the timing was off and fixed it for barely more than the diagnostic work. Now it seems to be running great. I think it must have just been off by one notch because I can't imagine it even running if it were off by more than that.

  • 2
    I had a timing belt slip by one notch and the car (130hp MR2) sounded like a lawnmower and could barely get to 30mph. I'm surprised yours ran as good as it did in that condition! :-) Commented Jan 16, 2013 at 12:46
  • Probably mine was off in the opposite direction. It wasn't just a slip but me re-aligning it after the slip and failing to get it exactly right. Commented Jan 16, 2013 at 21:23

This may sound stupid, but you changed the oil, right? It sounds like you haven't done much maintenance on the car, maybe this is what happens to a 20 year old engine when it is neglected.

  • Yes, I'd last changed the oil about a year before the head gasket blew, and I changed it again immediately after putting it back together and cleaning everything up. Also used a cleaning oil additive (before changing the oil). Commented Nov 20, 2012 at 0:55

You must log in to answer this question.

Not the answer you're looking for? Browse other questions tagged .