A Japanese car and motorbike manufacturer, noted for small, nimble cars like the swift, and bikes like the GSXR

learn more… | top users | synonyms

7
votes
2answers
239 views

Suzuku Katana does not start after an accident

I have a Suzuki Katana GSX600F. After an accident I was in, I rode the bike home and all was fine except a little cosmetic damage. In rainstorm it tipped over and after picking it up and trying to ...
2
votes
0answers
36 views

Manual vs Automatic Transmission Performance [duplicate]

I used to drive a Suzuki Khyber, 1989 model. It has a 1.0L 5 speed manual transmission. Recently I have shifted to Toyota Passo+Hana, 2008 model. It is 1.0L 4 speed automatic CVT transmission. Now ...
8
votes
3answers
6k views

2001 Suzuki Katana 600 motorcycle won't start

A few months ago I bought a used 2001 Suzuki Katana 600 with about 11,000 miles on it. I rode it without any issues for the first month or so. After that I started having occasional issues with ...
5
votes
3answers
3k views

Weak front brake on dirt bike

After changing the air tube in my front tire and reinstalling the wheel on my Suzuki RMZ450, I noticed that the front brake lost a lot of stopping power. What caused this and what do I need to fix to ...
10
votes
2answers
75 views

2003 Suzuki Katana GSX600F - No Start Issue

So I recently purchased this motorcycle from a third party. 2 days ago it would start up fine and you could ride it. The guy I brought it from said the battery was acting cranky so you should change ...
10
votes
1answer
115 views

Motorcycle Speed Wobble - How do I figure out the problem?

I have a 2005 GSXR 600. I took it for a test drive and the head shakes around 65mph or so and then goes away when I go past that. It's worse when I'm slowing down without the front brake. When I ...
8
votes
2answers
47 views

2002 Suzuki RM250 - Dies after warm up, restarts after cleaning wet plug

Has a fresh top end. Carburetor cleaned. Fresh fuel mix. Reed valve looks ok. Air filter and intake, ok. Has good spark. After it dies, the plug is wet. Restarts after cleaning plug? I ...
10
votes
3answers
99k views

Sloshing Sound Under Dash

I have a 2011 Suzuki SX4 Crossover AWD with MT. Sometimes when I start it up, begin moving forward, or quickly decelerate I can hear what sounds like water (or some other liquid) moving from one ...
1
vote
1answer
1k views

Change in engine oil colour immediately after oil change

I changed the engine oil of my Suzuki Swift VDI at 19,344kms (12020 miles) The car didn't even run 100 feet (about 30m) before I checked the oil again, and it was very black in color and had poor ...
3
votes
0answers
26 views

suzuki 85 lt 185 wont start [closed]

My quad was overheating bad and I didn't think about it and opened the oil cap like an idiot and it sprayed oil and smoke everywhere so I hurried up and shut it off and I tried to start it after it ...
7
votes
2answers
234 views

How to inexpensively replace missing baffles on a classic bike

Dilemma I have a 1980 Suzuki GS550L. Not only did one of the previous owners completely remove the baffles from the exhaust pipes, but they welded fender washers on the end of the pipes, so the OEM ...
8
votes
1answer
95 views

Ohlins Rear Motorcycle Shock - How do I setup, care for and tune it?

I have a 2005 GSXR 600 I'm getting on the road. I bought an Ohlins rear shock for it and ordered the spring to match my weight. I can't figure out the low/high speed or the rebound/compression ...
5
votes
1answer
60 views

1985 Suzuki lt185 cap starter problem

I recently purchased a 1985 suzuki lt185, the guy said it needs new recoil starter, and I bought a 86 recoil starter (all the other recoil starters I came across said fit 1984-1987 I went to go put it ...
3
votes
1answer
2k views

2003 Suzuki Katana 600 won't start

My bike doesn't want to turn over. It ran just fine last week, but something has changed. I have enough power with a new battery and I can hear the motorcycle trying to turn over. The exhaust pipe ...
3
votes
0answers
18 views

Intake boots for 79 GS1000 [closed]

I recently replaced the carbs on my 79 GS1000 Suzuki from 27MM to 36MM I modified some old Kawasaki intakes to fit by elongating the 2 mounting screw holes on intakes boots. The Bike runs great! but ...
9
votes
2answers
699 views

Motorcycle stood for over 12 months, turn over by hand first?

My 2006 GSXR 750 has been stood for over 12 months, I have drained the tank, and oil, and I'll do the coolant after I get it started, and give it another oil change. Is it worth me removing the plugs ...
6
votes
2answers
1k views

Suzuki GSXR600 (K7) - Burned regulator/rectifier

I have managed to completely fry regulator/rectifier on my Suzuki GSXR600 (K7). I suspect that it happened when I blindly splashed into a big water pond, so some water probably got on connector. Thing ...
4
votes
3answers
6k views

Bike is sometimes not wanting to shift into neutral

I have a 1982 Suzuki SP250. The bike "doesn't want" to shift into neutral sometimes. I have to rock it back and forth and shift up and down the gears a for a while before it shifts. I have changed the ...
6
votes
1answer
70 views

I scraped my car against my moms and i need to remove the white scratches

This morning, I scraped my car against my mom's car by accident. I noticed a white scuff above her rear driver tire as well on the front of my Suzuki xl7 with a dent. Can I get it out without taking ...
8
votes
1answer
54 views

Suzuki 2004 sv650s wiring

I got a 2004 sv650s Suzuki when I turn the key on the fuel pump does not come on and the CHECK light comes on on the dash. All the lights come on and the starter button does not work.All the fuses are ...
4
votes
1answer
89 views

Fork tube seals Suzuki sv650

So I recently inherited a 2002 Suzuki sv650... It was garage kept for about 6 years and needs some love. I noticed that the rubber seals on top of the fork shock tubes won't stay with the tubes... ...
2
votes
3answers
1k views

One cylinder not firing, GSX R 750 W

What could be possible reasons that one of the four cylinders (the left or first one) is not working? It was working before, than it did not, then it did again and now not again. I was able to start ...
4
votes
3answers
2k views

2001 Suzuki Katana 750 won't start after jump start and new battery

Bike has been running just fine. Recently left the lights on while at work, completely draining the battery. Couldn't get it push started there, but was able to get it jumped. I thought no biggie ...
8
votes
1answer
54 views

2000 Suzuki Grand Vitara 4x4 flashing

Whenever i engage my 4x4, the 4x4 light flashes. It didn't used to do this. Its annoying watching it flash. Any ideas what could be causing it to flash?
2
votes
1answer
44 views

I have a 2000 Suzuki Grand Vitara 5 Speed Ticking noise

I hear a ticking noise coming from the driver side rear end, possibly coming from the differential, not sure though because i checked out the pinion gear and i don't see any chips off any of the ...
4
votes
2answers
2k views

1999 gsxr 600 - What is wrong when my regulator keeps burning out?

I recently had my clutch replaced and a new battery put in. Within a month my regulator/rectifier burnt out of it. So, I purchased a new one. After 2 weeks that one burned out also. I replaced the ...
4
votes
1answer
569 views

How to let off the carburetors of a 1993 Suzuki GSX-R 1100 for winter storage?

My '93 Gixxer is in the shed for winter. I had it fully tanked, the shed is (moderately) warm, and every couple of weeks I attach a trickle charger to its battery. However, I know that there is still ...
4
votes
2answers
250 views

GSXR 1000 K5 turns off on hot days

My name is Joel from Sydney and I'm trying to diagnose a strange problem on my bike. Apologies if this is the wrong forum to be asking this question I'm new to this forum. Bike: GSXR K5 1000 Mods: ...
3
votes
1answer
205 views

A Suzuki GZ125 marauder that won't power on at all

I've been having a problem with my bike. I went to go to work in the morning and it turned on ok. Left to run for a few minutes then cut out. It turned over again and same thing ... I tried a third ...
5
votes
3answers
20k views

1994 Suzuki GSX600FR Katana - How do I know if motorcycle chain & sprocket need replacement?

I'm aware of how important they are, but have been coming up empty in my searches to determine if they're worn to the point of needing replacement. The service manual just says to inspect and replace ...
4
votes
2answers
140 views

Why does the bike idle lower after balancing carburetors?

I have just balanced my bike's carburetors (they were initially way out of sync) it idles lower and seems to smoke more when I rev it (smells rich). Returning it to it's previous out of sync setting ...
7
votes
3answers
955 views

Is it okay to run aviation fuel (100 low-lead) in a dirt bike?

I'm wondering if it will be okay to run 100 octane low-lead aviation fuel in my 2007 RM250 motocross bike (two-stroke). Half of the people I've asked say yes, while the other half say no. Will it be ...
0
votes
2answers
2k views

2001 katana won't start

2001 Suzuki Katana. Here is the story, after winter it fired up fine, just had a lag on the throttle. Pulled out air filter bike sounded like it loaded up and just died. I left it for a week. I went ...
3
votes
4answers
2k views

Suzuki Access stops running during rains

My Suzuki Access stops running even when there is very little rain or when there is very little water in the roads. Every time when I take it to the mechanic, there is water logged inside the air ...
3
votes
1answer
436 views

Bottom piece of spark plug broke off in motorcycle engine

I was riding my 2005 RM125 dirt bike the other day when it bogged down all of a sudden. I noticed the spark plug had backed out of the head, thus causing the stall. I pulled the spark plug all the way ...
5
votes
3answers
318 views

What is an inverted triangle piston skirt?

The recently launched Suzuki GSXR150 boasts an inverted triangle piston skirt. From what I have been told, it seems to be MotoGP technology which has been stripped down to suit a 150cc bike. Kindly ...
5
votes
4answers
4k views

What could be the reason and solution to a sudden drop in mileage?

Got my Suzuki Swift Diesel serviced two months back, and all of a sudden the mileage dropped from 20kmpl to 12kmpl and that is confusing! After i returned to Service shop, the guy said that there is ...
3
votes
1answer
90 views

Suzuki vl 250 wont start

I have a Suzuki vl250. It's been running great until last weekend I rode it home from work turned it off and the Mrs decided she wanted to go for a ride only problem is bike wont start! Since then I ...
9
votes
5answers
889 views

How to become a self-taught amateur mechanic?

I'm a computer systems engineer (we did a lot of embedded systems and some electrical at university) and I own a Suzuki SV650S. I am considering doing several upgrades to it (e.g. replacing the front ...
7
votes
2answers
878 views

Motorcycle transmission occasionally pops out of gear

I'm having an issue where the transmission will occasionally downshift by itself during a fast acceleration. I have a 2005 Suzuki Vstrom 650 and it's been a great bike so far. At pretty high revs, ...
2
votes
1answer
77 views

GSF400 Bandit carburetor model or type,

I have Suzuki Bandit GSF400 model '92. May I know the type of carb do I have on it? I am trying to do some replacement on jets but I need sizes.
2
votes
1answer
1k views

Suzuki Jimny 2009 shaking?

I have a Jimny model year 2009. When I get up to 80 km/h, the steering wheel shakes slightly; it does the same when braking from any speed above 80 km/h down to the 80 mark, but much more violently. ...
2
votes
0answers
103 views

What is Zongshen ZS125ST Carburetor 24mm KF Standard of Japan compatible with? [closed]

I have a carburetor "KF Standard of Japan" apparently Zongshen ZS125ST Carburetor 24mm KF Standard of Japan. What other makes/models is it compatible with?
0
votes
3answers
2k views

How to add Fog Lamps to Maruthi Suzuki Alto 800

I have a Suzuki Alto 800 lxi 2015 model and I would like to add Fog lamps for that, which is does not come with this model. But the Alto K10 has it. So I would like to modify it. Can I do that ? and ...
3
votes
1answer
1k views

How to determine what carburetors will be compatible with a motorcycle?

What are the parameters to determine whether or not motorcycle carbs are compatible with a certain engine? Is it just the size? For example, I have a 1978 Suzuki GS1000 with Mikuni carbs, and it's ...
3
votes
1answer
46 views

2005 Suzuki Katana stalls when put in gear

I have reworked all the carborators on the motorcycle. All seemed well but once it was put in gear, it stalled. What do I need to look for?
-1
votes
2answers
25 views

Bikes power is iffy [closed]

Hi I have a 03 katana and for some reason the bike won't power on anymore...I turn the key and nothing no lights nothing. I'm not sure if it's the battery or what. What should I do to trouble shoot ...
2
votes
1answer
228 views

2006 Suzuki SX4 Vibration/Lurch/Sound

My 2006 Suzuki SX4 (61k miles) has just started doing something odd that makes me a bit worried. There is an oscillating, deep sound that varies with the speed that I drive. It almost sounds like the ...
5
votes
1answer
453 views

Motorbike rear wheel hub reassembly

I want to get a new tire fitted on my 2003 Suzuki DR650 and removed the rear wheel. Following the manual I took the chain guard off, removed the axle, made the wheel free of chain and brake caliper ...
2
votes
2answers
106 views

Chain Tightening Guidance

I adjusted my chain, correctly, but some times when I check it, it feels to tight. If I roll the bike forward a bit it goes back to being correct looseness, is the normal?