Take the 2-minute tour ×
Motor Vehicle Maintenance & Repair Stack Exchange is a question and answer site for mechanics and DIY enthusiast owners of cars, trucks, and motorcycles. It's 100% free, no registration required.

UPDATE:

It has been a year and a half and it is now happening again! (same exact presentation.) It started happening again when it started getting cold out and is still going on now. Took it to the mechanic that swapped out the radiator and he's stumped.

No leaks, but couldn't the head gasket be leaking on the inside? How would I know if the head gasket needs replacing?


Been noticing lately that my heater stopped working and temp climbs to red. Came to find out that I had no coolant in engine.

Filled it up. Problem is that it still happens.

Now, radiator full, Heater works fine, but if I drive it for a while, temp climbs and heater stops working. Took it in. Mechanic said coolant pump was leaking. replaced it, and temp sensor.

still happens!

Here is how I can reproduce problem: Drive with high RPMs for about 15-20 minutes. I put it in Low 3, and got on the highway for about 10 minutes. This kept the RPM gauge up to about 4 or 5. temp gauge climbs rapidly once it decides to start.

I drove home after that point never letting the rpm gauge go higher than 1 and a half. (if I did, temp would rise rapidly). coasting in neutral makes it go down. The heater being on has no effect, however, once the temp gauge climbs rapidly, all heat from heater vanishes.

The heater starts working again if the temp goes down (meaning I lowered rpms long enough to let things cool down) when I got home I arranged it that I got back in the driveway with the temp gauge almost in the red. I then put the car in neutral and raced the engine, keeping the RPMs up to 5 for 2 minutes. It had no effect (temp did not climb) I let the engine cool down a little and tried again in Neutral. no go. unable to make temp climb while parked.

share|improve this question
    
Which engine does your Subaru have? The 2.5L? What mileage is on the engine? –  Timo Geusch Mar 28 '12 at 17:29
    
Did the mechanic replace the thermostat as well? Was it bled properly after all of those items were replaced? –  Dude318is Mar 28 '12 at 23:06
    
So the radiator swap mentioned below didn't solve the problem long term? –  Bob Cross Dec 8 '13 at 21:33
    
The thermostat and radiator cap was replaced. No changes –  KevinDeus Dec 12 '13 at 7:57
1  
Did you get it solved? Do you still need more information? –  Larry Dec 15 '13 at 18:09

4 Answers 4

Sounds like either air in the cooling system or a bad thermostat (although it'd be a weird failure mode for the thermostat). Strange that you can't reproduce it when the car's parked, though. How are your motor mounts? I'm just wondering if there could be a problem with one of them that allows the motor to move more than it should under load. This could stretch or kink some of the coolant lines (possibly), which might explain why your interior heat goes away too. Maybe take a look at any coolant lines you can identify and see if they show signs of creasing or twisting.

share|improve this answer
    
It would make sense why it would not happen while the car is in park. There is a difference when the engine is under load, for one, it heats up more. (my reason for driving in L3). –  KevinDeus Mar 30 '12 at 17:36

It sounds like a bad head gasket if everything else is in working order. Hot gases are introduced into the cooling system under load(hence why it goes down when you let off).

share|improve this answer
    
would it be a good idea for me to buy head gasket sealant as a precaution? (as in.. will it ruin an engine that is not leaking?) barsproducts.com/catalog/view/… –  KevinDeus Dec 7 '13 at 23:45

We wound up swapping out the radiator, and that solved it.

share|improve this answer
    
Based on your edit above, this didn't solve the problem - any other information? –  Bob Cross Dec 9 '13 at 12:44
    
no new behaviors have manifested. It presents the same now as it did before. (in my description above) –  KevinDeus Dec 12 '13 at 7:53
    
I guess its worth it to note that this started happening after a cold snap started here. I have been reading that cold weather can cause problems with the head gasket –  KevinDeus Dec 12 '13 at 7:56

They make a head gasket leak detector kit to determine if it's leaking. I would be surprised if you mechanic didn't have one. If he or she doesn't they are not that expensive.

Here is an example below

enter image description here

See my answer here for more info.

share|improve this answer
    
My mechanic did leak detection tests and said there were no leaks. As I only see this issue when the system is under load, I'd have to say that this method would only detect issues while the car is moving. –  KevinDeus Dec 15 '13 at 23:03
1  
@KevinDeus This is different from a leak test, did he use one of these or a pressure tester? The pressure tester won't always catch a head gasket leak. Combustion leak detectors will detect even a seeping head gasket if the directions are followed. This tool measures the amount of CO2 that's in the cooling system. –  Larry Dec 16 '13 at 0:50

Your Answer

 
discard

By posting your answer, you agree to the privacy policy and terms of service.

Not the answer you're looking for? Browse other questions tagged or ask your own question.